UNION OIL CO OF CA UNION 76 DIV- WESTERN RGION

7600 LOS ANGELES, CA 90017-1443 US

Cage: 79003

INJURY/DEATH. "EMPTY" DRUMS SHOULD BE COMPLETELY

RTECS: 9999999ZZ

SUPPLIER/DRUM RECONDITIONER. ALL OTHER CONTRS SHOULD

RTECS: 9999999ZZ

OR EXHAUST SYS MAY BE REQ. WHERE APPROP MIX MAY BE

RTECS: 9999999ZZ

SOLVENT,DEWAXED RESIDUAL OIL (PETROLEUM)

CAS: 64742-62-7

Fraction By Weight: 57%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3;10STEL(MIST)

MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: 40%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3;10STEL(MIST)

NO FIRST AID IS NORMALLY REQ; HOWEVER, IF

RTECS: 9999999ZZ

ACUTE ASPIR OF LRG AMTS OF OIL LADEN MATL MAY PRODUCE

RTECS: 9999999ZZ

OILS SHOULD BE FOLLOWED FOR DEVELOPMENT OF LONG-TERM

RTECS: 9999999ZZ

CAN PRODUCE CHRONIC INFLAMM OF LUNGS (I.E. LIPOID

RTECS: 9999999ZZ

ARE SUBTLE & RADIOLOGICAL CHANGES APPEAR WORSE THAN

RTECS: 9999999ZZ

UPPER RESP TRACT, SHORTNESS OF BREATH W/EXERTION,

RTECS: 9999999ZZ

BELOW CURRENT WORKPLACE EXPOS LIM IS UNLIKELY TO

RTECS: 9999999ZZ

MATL FROM ENTERING SEWERS, STORM DRAINS, &

RTECS: 9999999ZZ

ABSORBED INTO AN APPROP MATL. NOTIFY FIRE

RTECS: 9999999ZZ

OF ANY SPILL IS REC. IF SPILL IS MADE INTO US

RTECS: 9999999ZZ

NOTIFY THE NATIONAL RESPONSE CENTER (800-424-8802)

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE MILD IRRIT. DIRECT CONT
W/LIQ/EXPOS TO VAPS/MISTS MAY CAUSE STINGING, TEARING & REDNESS.
SKIN:MAY CAUSE MILD IRRIT. PRLNGD/RPTD CONT MAY CAUSE REDNESS,
BURNING & DRYING & CRACKING OF SKI N. INHAL:BRTHG HIGH CONC OF
VAPS/MISTS MAY CAUSE IRRIT OF NOSE & THORAX. INGEST:INGEST OF
EXCESS (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:QUANTITIES MAY CAUSE IRRITATION OF
DIGESTIVE TRACT.
Medical Cond Aggravated by Exposure:PERSONS WITH PREEXISTING SKIN
DISORDERS MAY BE MORE SUSCEPTIBLE TO EFFECTS OF THIS MATERIAL.

First Aid:EYE:MOVE VICTIM INTO FRESH AIR. FLUSH EYES W/CLEAN WATER FOR
AT LEAST 15 MINUTES. IF SYMPTS PERSIST, SEEK MD ATTN. SKIN:WIPE
MATL FROM SKIN & REMOVE CONTAM SHOES & CLTHG. CLEANSE AFFECTED
AREA(S) THOR O W/MILD SOAP & WATER &, IF NEC, A WATERLESS SKIN
CLEANSER. IF IRRIT/REDNESS DEVELOPS & PERSISTS, SEEK MD ATTN.
INHAL:MOVE VICTIM INTO FRESH AIR. IF SYMPT (SUPDAT)

Flash Point:453F/234C

Spill Release Procedures:MAY IGNITE. KEEP ALL SOURCES OF IGNIT AWAY
FROM SPILL/RELEASE. STAY UPWIND & AWAY FROM SPILL/RELEASE. ISOLATE
AREA & LIM ENTRY TO AUTHORIZED PERSONNEL. STOP SPILL/RELEASE IF IT
CAN BE DONE W/OUT RISK. WEAR APPROP PROT EQUIP. PREVENT SPILLED
(ING 11)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:USE & STORE MATL IN COOL, DRY, WELL
VENT AREAS AWAY FROM HEAT & ALL SOURCES OF IGNIT. KEEP CONTRS CLSD.
STORE ONLY IN APPRVD CONTRS.
Other Precautions:PROT CONTRS AGAINST PHYSICAL DMG. "EMPTY" CONTRS
RETAIN RESIDUE & CAN BE DANGEROUS. DO NOT PRESS, CUT, WELD, BRAZE,
SOLDER, DRILL, GRIND/EXPLODE SUCH CONTRS TO HEAT, FLAME,
SPARKS/OTHER SOURCES OF IGN IT; THEY MAY EXPLODE & CAUSE (ING 15)

Respiratory Protection:USE OF NIOSH/MSHA APPROVED RESP IS ADVISED WHEN
CONC EXCEED ESTABLISHED EXPOS LIM. DEPENDING ON AIRBORNE CONC, USE
A NIOSH/MSHA APPROVED RESP/GAS MASK W/APPROP CARTRIDGE &
CANNISTERS/SUPPLIED AIR EQUI P.
Ventilation:IF CURRENT VENT PRACTICES ARE NOT ADEQ TO MAINTAIN AIRBORN
CONC BELOW ESTABLISHED EXPOS LIM, ADDITION VENT (ING 17)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:A SOURCE OF CLEAN WATER SHOULD BE AVAILABLE
IN WORK AREA FOR FLUSHING EYES & SKIN. IMPERVIOUS CLTHG SHOULD BE
WORN.
Work Hygienic Practices:WASH THORO AFTER HANDLING. DO NOT WEAR CONTAM
CLTHG/SHOES. USE GOOD PERSONAL HYGIENE PRACTICES.
Supplemental Safety and Health
FIRE FIGHT PROC:RISK. WATER SPRAY MAY BE USEFUL IN MIN/DISPERSING VAPS
& COOLING EQUIP EXPOS TO HEAT & FLAME. AVOID SPREADING BURNING LIQ
W/WATER USED FOR COOLING PURPOSES. FIRST AID PROC:PERSIST, SEE K MD
ATTN. IF NOT BRTHG, IMMED BEGIN ARTIF RESP. IF BRTHG DFCLT, ADMIN
O*2. SEEK IMMED MD ATTN. (ING 4).

Hazardous Decomposition Products:COMBUSTION MAY YIELD MAJOR AMOUNTS OF
CO*X & MINOR AMOUNTS OF SO*X & NO*X.

Product ID:04865, UNICOL VISLUBE 220
MSDS Date:01/01/1987
FSC:9150
NIIN:00N017613
MSDS Number: BPJNV

Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.